A.Jaki’s Garage

A.Jaki’s Garage Contact information, map and directions, contact form, opening hours, services, ratings, photos, videos and announcements from A.Jaki’s Garage, Automotive repair centre, Clonmany Glebe, Lifford, County Donegal, Clonmany.

18/11/2023

•Diagnose and replace bad Cdi box. Strip exhaust, tank, plastics. Set timing as it was set wrong. Adjust valve clearances to spec with Hot Cams shims. Make brackets for a light bar and wire in. Refit plastics, exhaust etc. , l**e chain and maintenance clean.

Ford Transit Connect 1.8Tdci A lot of work carried out with this one with the notorious wet belt failure. New engine got...
17/11/2023

Ford Transit Connect 1.8Tdci

A lot of work carried out with this one with the notorious wet belt failure. New engine got an overhaul beforehand, a lot of ancillary parts different between Mondeo and Connect engine.
General tidy up with a bit of spraying too.

Parts swapped over to Mondeo engine:

Flywheel ✅
Gearbox ✅
Oil filter housing ✅
Power steering mount ✅
Ps pump ✅
Alternator bracket ✅
Alternator ✅
AC pump ✅
EGR cooler ✅
EGR water pipes ✅
High pressure oil feed ✅
Exhaust manifold studs ✅
Sump ✅

Work Carried Out:

Fit wet timing belt ✅
Crankshaft pulley seal ✅
High pressure pump seal ✅
High pressure pump belt ✅
Water pump ✅
Clutch ✅
Release bearing ✅
Gearbox mount ✅
Diesel filter ✅
Oil+filter ✅
Gearbox oil✅
Starter ✅
Paint chassis legs ✅
Paint rad support ✅
Spray bonnet and bumper ✅
Tidy back bumper ✅
Front discs and pads ✅
Drop links ✅
Exhaust flexi ✅
Indicator stock (customer requested)✅
GEM module diagnosed an replaced ✅
Number plate lights ✅
Fog lights ✅

Berlingo Clutch Replacement ✅
17/11/2023

Berlingo Clutch Replacement ✅

Honda 350•New piston and rings✅•Cylinder✅•Gasket set✅*Strip and rebuild top end. New piston, rings, cylinder and gaskets...
17/11/2023

Honda 350

•New piston and rings✅
•Cylinder✅
•Gasket set✅

*Strip and rebuild top end. New piston, rings, cylinder and gaskets. Wire fan to come on with ignition switch (customer requested).

LT80 engine rebuilt and cleaned up after lying in a shed for years. New carburettor, petcock, new brake cables and chain...
10/10/2023

LT80 engine rebuilt and cleaned up after lying in a shed for years. New carburettor, petcock, new brake cables and chain. Original cause of seizing was a failed 2 stroke oil pump. Good clean up then to remove overspray and years of dirt built up 👍

B6 Passat for some maintenance.Discs and pads all round✅Front and rear spring ✅Strut top bearing ✅Rear abs sensor ✅Rear ...
29/09/2023

B6 Passat for some maintenance.

Discs and pads all round✅
Front and rear spring ✅
Strut top bearing ✅
Rear abs sensor ✅
Rear wheel bearing ✅

Predator 500 complete engine rebuild. Big end con rod bearing failure along with scored piston. New crank, piston kit an...
29/09/2023

Predator 500 complete engine rebuild. Big end con rod bearing failure along with scored piston. New crank, piston kit and gaskets to complete rebuild ✅

Seat Exeo Gearbox mount replacement, done mobile as the car couldn’t be driven. Saved cost of recovery truck to the gara...
29/09/2023

Seat Exeo Gearbox mount replacement, done mobile as the car couldn’t be driven. Saved cost of recovery truck to the garage as it was a relatively straightforward job 👍

A Ford Transit pick up that needed an extensive amount of work to pass the test. All work carried out by myself and then...
03/09/2023

A Ford Transit pick up that needed an extensive amount of work to pass the test. All work carried out by myself and then retested passing first time👍

Front right track rod end (align)✅
Front right drop link✅
Front left drop link✅
Front left ball joint✅
Rust holes on chassis above axle✅
Replace metal brake pipes✅
Rust hole on sill inside rear left door ✅
Rust holes both outer sills ✅
Rust hole passenger inner sill ✅
Replace clutch and flywheel ✅
Replace rear main seal✅
Replace hardly splicer ✅

Another Couple of very tidy LT50s 🟡⚪️Yellow•Remove plastics ✅•Strip, clean and rebuild carb ✅•Remove side casings and fl...
01/08/2023

Another Couple of very tidy LT50s 🟡⚪️

Yellow

•Remove plastics ✅
•Strip, clean and rebuild carb ✅
•Remove side casings and flywheel and replace crank seal ✅
•Clean and re-oil air filter ✅
•Tune carb ✅
•New fuel line and clamps ✅
•New spark plug ✅
•Kill switch wiring ✅
•Check gear oil ✅
•Tighten breaks ✅
•Tighten chain ✅
•Install in-line filter ✅
•Oil chain ✅
•Maintenance clean ✅

White

•Remove plastics ✅
•Clean and re-oil air filter ✅
•Tune carb ✅
•New spark plug ✅
•Check gear oil ✅
•Replace spring in recoil starter ✅
•Install in-line filter ✅
•Tighten chain ✅
•Oil chain ✅
•Maintenance clean ✅

LT50 Jigsaw Puzzle 🧩😅Engine was locked up due to magnets on flywheel delaminating and binding up, also took the stator o...
01/08/2023

LT50 Jigsaw Puzzle 🧩😅

Engine was locked up due to magnets on flywheel delaminating and binding up, also took the stator out with them. Good used second hand flywheel and stator sourced and fitted. Pull cord rewound. Rear brakes fixed. Welded broken exhaust at silencer joint. Fresh VHT paint on exhaust. Repainted the frame and wheels and plastic welded all the cracks in fenders.✅

Ford Focus serviced and tidied up before sale 👌
05/07/2023

Ford Focus serviced and tidied up before sale 👌

Address

Clonmany Glebe, Lifford, County Donegal
Clonmany
F93

Website

Alerts

Be the first to know and let us send you an email when A.Jaki’s Garage posts news and promotions. Your email address will not be used for any other purpose, and you can unsubscribe at any time.

Shortcuts

Share

Category