AGC Gearboxes and Clutches

AGC Gearboxes and Clutches AGC Gearboxes and Clutches LTD offer a 12 month repair guarantee with reliable service, collection and delivery. Vehicle repair, fully VAT registered.

Specialising in gearbox repairs and reconditioning.

Another Nissan juke cvt in for unwanted noises when driving. Once inspected it showed internal bearing failure. We remov...
05/06/2026

Another Nissan juke cvt in for unwanted noises when driving. Once inspected it showed internal bearing failure. We removed the gearbox , stripped down entirely and clean. Replaced the internal bearing with the latest revision upgrade and supplied new filters (not many know that there are 2 filter in the gearbox). Back together and fresh oil later the juke was back fighting fit. Thank you for choosing AGC

Ford Kuga recovered in to us from a warranty company we are pre approved to carry work out for. This Kuga had let its ow...
05/06/2026

Ford Kuga recovered in to us from a warranty company we are pre approved to carry work out for. This Kuga had let its owner down on the motorway which caused her some distress without a doubt. We removed the gearbox to determine faults and it didn’t take long. It’s was very clear to see the clutch had fully burnt out and wasn’t able to create enough friction to drive the vehicle. Quick phone call on the customers behalf to their warranty company and authorised straight away. All work carried out in a prompt manner and she was very grateful. Thank you for choosing AGC

Seat in with DSG issues which caused the miss-selection or failed to select certain gears when warmed up. Some diagnosti...
05/06/2026

Seat in with DSG issues which caused the miss-selection or failed to select certain gears when warmed up. Some diagnostic work carried out confirmed issues within the pressure sensors of the mechatronic unit. We replace both sensors in this scenario to ensure a good repair is carried out as well as flush and service the gearbox at the same time. Adaptation of the internal wet clutch system carried out once repairs where complete due to the system is learned and can cause a jolty selection later down the line if the correct procedure isn’t carried out. Thank you for choosing AGC

2015 vw polo recovered in with a ear rattling noise when the clutch pedal isn’t pressed. It had been suggested to them i...
05/06/2026

2015 vw polo recovered in with a ear rattling noise when the clutch pedal isn’t pressed. It had been suggested to them it’s potentially the gearbox or flywheel. Once the gearbox had been removed it was very clear the dual mass flywheel had collapsed. Luckily once some of the flywheel bolts were undone it popped back into position and we were able to remove without having to spend undue time cutting the flywheel to access the rest of the bolts. Vw have now discontinued the dual mass on the particular polo (1.4 Tdi) and now suggest a solid mass flywheel conversion with some software version to suit. This customer had been recommended to us via another very happy customer we carried work out for previously on their daughter Audi A1. Thank you for the reconditions and thank you for choosing AGC.

2017 Astra recovered in for no gear selection. Inspection showed issue with clutch hydraulic release bearing failure. We...
08/05/2026

2017 Astra recovered in for no gear selection. Inspection showed issue with clutch hydraulic release bearing failure. We replaced the entire system inc the clutch master cylinder for good measure. Customer back on the road in no time. Thanks for choosing AGC

Peugeot 3008 recovered in by 1 of the many warranty companies we deal with. This car had no drive due to not being able ...
08/05/2026

Peugeot 3008 recovered in by 1 of the many warranty companies we deal with. This car had no drive due to not being able to select gear. Once the gearbox was removed it’s very clear to see the clutch release bearing had seized up and caused a fair amount of issues and damage. Gearbox assessed and deemed scored but usable however we did replace the whole dual mass flywheel and clutch system with new bearing flute for the gearbox. All dealt with in house on behalf of the customer through their warranty provider. Thank you again

Customers Tiguan in for a suspected broken clutch sprung spacer and possible cut into gearbox casing. Once gearbox remov...
24/04/2026

Customers Tiguan in for a suspected broken clutch sprung spacer and possible cut into gearbox casing. Once gearbox removed it was very clear to see the input seal had developed a leak a mere £20 seal can cause so much carnage. Never the less gearbox was checked over and deemed good , new seal for the input shaft and new flywheel and clutch kit (mainly due to contamination for obvious reasons) and we have another happy customer. Thanks for choosing AGC

Customers golf r pushing some serious power which developed a wet dual clutch slip. They sourced their own upgraded part...
24/04/2026

Customers golf r pushing some serious power which developed a wet dual clutch slip. They sourced their own upgraded parts from abroad and approached us to fit them. We are more than happy to do so and once fitted adapted the r was back ready for the road and in time for our customers show. Thanks for choosing AGC

As promised , another Ford power shift in for virtually the same issue as the previous. It’s a growing trend unfortunate...
17/03/2026

As promised , another Ford power shift in for virtually the same issue as the previous. It’s a growing trend unfortunately which boils down to lack of gearbox servicing. This vehicle had a new gearbox fitted by Ford 5 years ago but un be known to the new owner it had been well overdue a gearbox service and ultimately suffered failure resulting in a full strip down and complete overhaul. Never the less the customer was happy with our service and thankful for the quick turn around. Thanks for choosing AGC

Ford s max in for power shift gearbox issues. We are quite hurst in these gearboxes by now as I’m sure you can tell if y...
16/03/2026

Ford s max in for power shift gearbox issues. We are quite hurst in these gearboxes by now as I’m sure you can tell if you follow us. Strip down of the gearbox showed the plastic spacers in between the clutch housing had broken apart and cycled the gearbox area getting caught up by the internal filter. After restricting the oil it then proceeded to burn a clutch out and was almost in drivable. We got the job done and another happy customer back on the road. Stay tuned for its twin coming soon. Thanks for choosing AGC

Address

Unit 21
Bolton
BL26BD

Opening Hours

Monday 9am - 5:30pm
Tuesday 9am - 5:30pm
Wednesday 9am - 5:30pm
Thursday 9am - 5:30pm
Friday 9am - 5:30pm

Telephone

+441204391151

Website

Alerts

Be the first to know and let us send you an email when AGC Gearboxes and Clutches posts news and promotions. Your email address will not be used for any other purpose, and you can unsubscribe at any time.

Contact The Business

Send a message to AGC Gearboxes and Clutches:

Shortcuts

Share

Category